Leeham News and Analysis
There's more to real news than a news release.
Airbus and Boeing 2022 orders and deliveries
By Bjorn Fehrm
January 10, 2023, © Leeham News: Airbus and Boeing released their 2022 delivery and order data today. With a delivery of 661 airliners, Airbus is a 38% larger supplier than Boeing at 480 aircraft.
Airbus had a target of 700 deliveries but came short due to supplier constraints in a year of COVID recovery, raising energy prices due to the war in Ukraine and labor shortages. Boeing is not out of a tunnel caused by 737 Max crashes and 787 quality problems.
On the order side, Airbus booked 820 net orders versus Boeing’s 774. The Airbus backlog is 33% larger at 7,239 aircraft versus Boeing’s 5,430 jets.
Outlook 2023: ramping up production at Airbus
Leeham News in addition to Twitter, Facebook and Linkedin, may now be found on Post.news here and on Mastodon here.
Subscription Required
By Vincent Valery and Scott Hamilton
Introduction
Jan. 2, 2023, © Leeham News: LNA wrote a year ago that ramping up single-aisle production would be Airbus’ major 2022 challenge. Increasing narrowbody aircraft production on the A220 and A320 lines proved more difficult than envisioned for the European OEM.
The war in Ukraine, which led to sanctions and higher energy bills, compounded the challenges for Airbus and its supply chain. Among the suppliers behind delivery schedules, engine manufacturers received the most attention earlier in the year. The situation has improved since then.
Airbus did not launch any new aircraft variants in 2022. While the A321XLR flight campaign started in June 2022, the program has accumulated a six-month delay. Entry into service is now planned for 2Q2024 instead of 4Q2023. The delays are caused mainly by the certification of the new rear center fuel tank into the fuselage.
Despite a production line full for several years, Airbus continued accumulating healthy numbers of A320neo orders, including from Chinese carriers. The cancellation of AirAsia X’s A330neo order improved the family’s order book quality. Net orders for the A350 family, including the freighter variant, have been muted but should pick up as long-haul traffic recovers. Airbus’ low point has been the ongoing court battle with Qatar Airways on the A350 paint issue, leading to the cancellation of the carrier’s order book.
Last but not least, Airbus announced many ecoAviation and sustainability initiatives throughout the year, culminating at its Annual Summit Nov. 30-Dec. 1.
Will 2023 be more of the same for the European OEM?
Summary
- Behind-schedule ramp-up on both single-aisle lines;
- New orders will determine the pace of the twin-aisle ramp-up;
- Avoiding further A321XLR certification delays;
- Robust cash flows allow sizable R&D spend on ecoAviation;
- No new product development and more A330neo orders?
Pontifications: LNA’s Top 10 stories of 2022
Dec. 26, 2022, © Leeham News: This year has been a year of recovery.
By Scott Hamilton
Recovery from the COVID-19 pandemic. Recovery from shortages in the supply chain, layoffs during the pandemic and from financial losses. Boeing continues to struggle in its recovery from the 2019 grounding of the 737 MAX and 2020 suspension of deliveries of the 787.
This year saw a resumption of the big international European air shows since the pandemic—Farnborough. There was great anticipation that Boeing was working on new airplane programs in earnest for the first time in three years.
And disappointments.
Here’s a review of the Top 10 stories LNA published, by readership.
Leeham News in addition to Twitter, Facebook and Linkedin, may now be found on Post.news here and on Mastodon here.
HOTR: Supply chain hurts A220 assembly flow, big push to meet year-end delivery target
By the Leeham News Team
Dec. 20, 2022, © Leeham News: Airbus’ woes with the A320 family production line are widely reported. So are Boeing’s woes with the 737 line.
Less well reported are the woes Airbus has with the A220 production lines in Montreal and Mobile (AL).
LNA was informed two weeks ago that the A220 line is its own serious production challenges traced to the supply chain. Rumors circulated that Airbus may shut down the lines to allow the suppliers to catch up.
Airbus’s Montreal office acknowledged challenges but denied the final assembly lines were going to be or were considered for shut down temporarily.
“In order to protect our operations in a complex environment, some ad hoc short-term planning adjustments have been made to align with our supply chain in order to protect our deliveries to our committed customers. We continue to focus on the aircraft that are almost ready for delivery in 2022 and there is no shutdown either of FALs nor pre-FALs planned,” a spokesperson emailed LNA.
United orders 100 Boeing 787s, 100 Boeing 737s, defers Airbus A350 again
Dec. 13, 2022, © Leeham News: United Airlines today announced a massive order for 100 Boeing 787s and 100 Boeing 737 MAXes. Sub-types weren’t announced. Neither were the engine types for the 787s, which are powered by either GE Aerospace’s GEnx or Rolls-Royce Trent 1000.
An order for 45 Airbus A350s was deferred again, this time to at least 2030. Deliveries were to begin in 2027. The order had been deferred at least twice previously. Reuters reported “United CEO Scott Kirby told reporters ‘the right time for 350 versus (787) conversation is when we’re replacing the bulk of the 777s, which really doesn’t begin to the end of the decade.’” Most observers believe this order will be canceled eventually.
Related articles
At least one more big airline order, Air India, is expected before the end of the year.
Pontifications: The Queen is Dead. Long live the Queen.
By Scott Hamilton
Dec. 12, 2022, © Leeham News: The 1,574th Boeing 747 rolled off the production line last Tuesday. The last one, after 53 years of continuous production. The iconic aircraft was known as the Queen of the Skies.
The larger A380 didn’t replace the 747. McDonnell Douglas’s DC-10 and MD-11 didn’t replace it. The Lockheed L-1011 didn’t replace it. Neither did Boeing’s own 777-300ER. And neither will the 777X. The 777-X does not replace the 747—it succeeds the 747. I don’t think that anyone will characterize the 777X as “the Queen of the Skies.” The X looks like any other airplane. The 747 look is unique (a well-worn, overused word that in this case applies) and iconic. It has a nose door. The 777XF does not.
The Queen is Dead. Long live the Queen.
The last Boeing 747 to be built rolled off the Everett factory line Dec. 6, 2022. Line No. 1574 is for Atlas Air. After painting, a decal of legendary engineer Joe Sutter, the father of the 747, will be applied to the starboard side. Photo credit: Leeham News.
As it turns out, there was a debate within Boeing as far back as 2004 about whether to cancel the 747 program then. The 777-300ER was just entering service. There was a recognition within Boeing that the -300ER was the beginning of the end for the 747.
I tell this story in my book, Air Wars, The Global Combat Between Airbus and Boeing. Also in the book is the story about how Boeing tried to launch the 747-500 and 747-600, without success. Airbus won this competition, launching the A380 with Singapore Airlines and in the process killing the 747 derivatives. But Phil Condit, then the CEO of Boeing, wasn’t upset. Something else was in the hopper.
Below is a synopsis of these stories, excerpted from Air Wars.
HOTR: Tuesday’s Boeing announcement may give indication of A350 future at United
By the Leeham News Team
Dec. 9, 2022, © Leeham News: The engine selection on a big Boeing 787 to be announced Tuesday may be the most definitive signal yet of what United Airlines will do with its oft-deferred Airbus A350 order.
United is considered certain at some point to cancel its orders for 45 A350s. This order has been deferred several times. The new order to be announced Tuesday for up to 100 or more Boeing 787s adds to the more than 60 already in the fleet. United clearly doesn’t need a large fleet of 787s and a smaller fleet of A350s.
But canceling the Airbus order is not without some cost. It’s believed that penalties to Airbus are manageable. These also may be mitigated by an order for A321neos. This can solve Airbus’s concerns. But it does nothing for Rolls-Royce, which provides the engines for the A350s.
Rolls is not an engine supplier for the A321neo. United’s swapping the A350 for the A321 means Rolls loses that future business. What’s the mitigation for Rolls?
United may split the engine order for the 787 between incumbent GE Aerospace and Rolls. If the engine selection is announced Tuesday and the order is split, this will be the clearest indication yet that the A350 order will be history. United and Boeing scheduled a press conference at the 787 production and assembly plant in Charleston (SC).
HOTR: Big airplane orders race toward year end
Dec. 8, 2022, © Leeham News: A year-end aircraft order rush will benefit Airbus and Boeing, according to what LNA is hearing.
Air India
Airbus appears in line to win 50-100 A350 orders from Air India. Boeing appears in line to win an order from the carrier for 100 new-build 737 MAXes and—get this—40 MAXes that were built for China and which have been in storage since 2019. As previously reported, there were about 140 MAXes built for the Chinese. Boeing said in September it couldn’t wait any longer for China to reopen the domestic market to Boeing for the MAXes. Remarketing the airplanes began then.
The Boeing order could be signed as early as this week or next. The Airbus deal is expected by year-end.
Saudi Arabia
Saudi Arabia is expected to agree to an order for around 50 A350s. The new airline, RIA, which will compete with the current flag carrier, Saudi, is expected to be the prime beneficiary. Airbus hopes to conclude the deal by year’s end if not earlier.
Boeing is not in line for an order this year, according to what HOTR hears. But negotiations begin soon.
The Economics of the 767 and A330 at Seven and Eight abreast
Subscription Required
By Bjorn Fehrm
Introduction
Dec. 8, 2022, © Leeham News: In a previous article, we started speculating what an NMA type of aircraft would look like based on a Boeing 767 cross-section. An airliner’s cross-section decides the design of a large number of parts in an airplane.
In essence, a fuselage is a tube with a constant cross-section where the constant parts are repeated framewise to form the fuselage. It’s finished with a tapering forward cockpit and a rear tapering empennage.
We now look at what could have been a passenger version of an NMA that would have used the Boeing 767 cross-section with adaptations. To understand its economic impact, we make a comparison where we take a standard 767-300ER, then modify it to an NMA type fuselage and compare it to the competition in the size class, the A330-200 and -800.
As before, we do this by flying the world’s busiest long-haul route, London Heathrow, to New York JFK.
Summary
- An NMA based on an improved 767 fuselage cross-section would have been a very competitive airliner
- I would be the ideal replacement for the Boeing 757, 767, and 787-8.
Airbus Summit Showcases Sustainability Status
By Bjorn Fehrm
December 7, 2022, © Leeham News was at Airbus Summit: Airbus briefed media and influences on its Sustainability progress during briefings in Toulouse and Munich last week. Here is an update on where Airbus is with its programs.
The overall impression is of tangible progress on techno brick research and development and echo systems programs like SAF production and hydrogen supply and ground infrastructure.
At the summit, key customers like Airlines, technology partners, and leasing companies were part of the panels, giving the customer perspective and the view of the passengers.
Figure 1. The test setup of the Airbus fuel cell turboprop engine on its A380 test aircraft. Source: Airbus.