Leeham News and Analysis
There's more to real news than a news release.
Leeham News and Analysis
- Bjorn’s Corner: Air Transport’s route to 2050. Part 25. June 6, 2025
- New RISE powerplant benefits from decades of GE research and development June 5, 2025
- Engine makers emphasizing durability, reliability June 4, 2025
- Boeing CEO: Lessons learned are key to certification of 737-7/10 and 777X June 2, 2025
- Digital twin is a key to JetZero’s hopes for Blended Wing Body entry June 2, 2025
Single-aisle or Widebody over the Atlantic on thin routes?
Subscription Required
By Bjorn Fehrm
Introduction
October 28, 2021, © Leeham News: The headline seems like a no-brainer. On long thin routes over the Atlantic, we have learned a Boeing 757, or its replacement, the Airbus A321LR, is the right aircraft (as long as it’s within its range).
This was the situation in a pre-pandemic market where freight yields were half of today. The single-aisle has lower operating costs than the widebodies, and if the passenger stream and range fits, it was the transport to have on the route.
With the high cargo prices, does this change? We check for several Atlantic routes.
Summary
- The increased yields for air cargo challenge the mantra; a single aisle is preferred for trans-Atlantic service as long as the passenger number and range fits.
- Going forward it will be all about the cargo prices and the number of passengers to transport.
Update 1: Boeing posts small operating profits, net losses in 3Q and nine months (with CNBC comments)
Oct. 27, 2021, © Leeham News: Boeing reported small operating profits and small net losses for the third quarter and nine months.
The third quarter operating profit was $329m and $1.27bn for the nine months. Boeing lost $401m and $4.7bn for the periods in 2020.
Operating cash flow used in the third quarter declined to $262m and $4.1bn compared with $4.8bn and $14.4bn used in 2020. Additional cash was used for spending on property, plants and equipment. Boeing had $20bn in cash at Sept. 30, down slightly from June 30’s $21.3bn. Consolidated debt declined from $63.6bn at June 30 to $62.4bn at Sept. 30.
HOTR: Lessors warn Airbus
By the Leeham News team
Oct. 26, 2021, © Leeham News: Two mega-lessors warned Airbus against dramatically upping production rates of the A320 family, London’s Financial Times reported Oc
t. 23.
“[B]old plans to speed up production are unjustified given still subdued demand from airlines after the coronavirus pandemic,” The Times wrote. Airbus notified suppliers earlier this year to study going to a production rate of 70 aircraft per month by 2025. Rates might go even higher, to 75/mo, Airbus said.
“The chief executives of Avolon and AerCap, wrote to Guillaume Faury, Airbus chief executive, in recent weeks to express their concerns that the aircraft market would not support the most aggressive increases in output rates, according to four people familiar with the situation. A surge in supply of new aircraft, potentially flooding the market, could push down the value of the lessors’ existing fleets. They make their money by renting to airlines,” the paper wrote.
Airbus sees encouraging signs of wide-body demand recovery
Subscription required
By Scott Hamilton
Oct. 25, 2021, © Leeham News: Airbus sees some “encouraging” signs wide-body demand is recovering from the global COVID-19 pandemic.
Christian Scherer. Source: Airbus.
Passenger demand is nearing-pre-pandemic levels in key areas of the world where single-aisle aircraft are used. Long-haul international demand remains suppressed, however. Some don’t forecast a return to normal for up to two more years. Others forecast a recovery on key routes next year.
Christian Scherer, the chief commercial officer for Airbus, is optimistic.
“I would say that on the wide-body market, you see encouraging signs,” he said during a press gaggle at the IATA AGM Oct. 3-5 in Boston. “Maybe that has to do with the fact that the ecosystem at large is realizing that the best thing they can do in the short- and medium-term, towards that whole global objective of sustainable air transportation is to equip themselves with the most fuel-efficient and therefore eco-friendly airplanes.
“I think that against that backdrop and the opening of more international corridors sees a regained interest on the wide-body side as well. Now it’s lagging the single arch really and there is no scoop here that rates in the long-range airplanes are going to change imminently, but the general sentiment is positive on the wide-bodies as well and that’s really good.”
Pontifications: Engines drive timing of new Embraer TPNG
The first report appeared Oct. 18, 2021.
By Scott Hamilton
Oct. 25, 2021, © Leeham News: Embraer appears marching toward launching a new turboprop aircraft next year with a targeted 2027 entry into service.
The timing will be determined by the engine. Pratt & Whitney, GE Aviation and Rolls-Royce have development programs. PW and GE are farthest along. PW is thought to have the best chance of winning Embraer’s business. (Pratt & Whitney supplies the engines for the E2 jet. GE supplied the engines for the E1.)
In an interview at the IATA AGM Oct. 3-5 in Boston, Arjan Meijer, the president of Embraer Commercial Aviation, said the competition remains open today.
Bjorn’s Corner: The challenges of airliner development. Part 26. Maintenance planning
By Bjorn Fehrm, Henry Tam, and Andrew Telesca.
October 22, 2021, ©. Leeham News: Last week, we looked into Continued Operational Safety and there specifically Safety Monitoring and Reporting. Now we look at the role Instructions for Continued Airworthiness (ICAs) play in preventing the air safety issues we talked about last week.
An important part of the Instructions for Continued Airworthiness, ICA, is how to maintain the aircraft in a continued airworthy state during its operational life. The aircraft is airworthy when it rolls out of the factory but it needs to keep this condition for its 25 years or longer productive life. How this is done is contained in the maintenance documents, but there is more to it than just producing a maintenance manual.
Figure 1. The Aircraft Maintenance Manual (AMM) for the Boeing 747, part of ICA for the 747. Source: Boeing.
Single or twin Aisle for cargo rich routes?
Subscription Required
By Vincent Valery
Introduction
Oct. 21, 2021, © Leeham News: LNA started the cargo-themed series by comparing factory and converted freighter aircraft performance. We followed with the comparison of cargo capacity for different passenger airliners with the same low number of passengers.
The latter showed that freight revenues alone could justify operating a larger variant despite lower passenger load factors. We now continue the cargo-themed series from a different angle.
Several countries, notably the United Kingdom, United States, and Singapore, re-opened quarantine-free travel for non-residents who received a COVID-19 vaccine. After more than 18 months of depressed passenger traffic, airlines are hopeful long-haul traffic will finally restart in earnest.
It will probably take a few more years until long-haul traffic fully recovers to pre-pandemic levels globally. With that in mind, airlines need to decide how to rebuild their long-haul networks gradually.
Launched a few months before the COVID-19 pandemic, the A321(X)LR seems an ideal aircraft to test the market before committing to larger aircraft. LNA has extensively written about the pre-COVID-19 long-haul market fragmentation with the smaller twin-aisle (A350 and 787) and higher-range single-aisle (737MAX and A321LR) aircraft.
However, is a long-range single-aisle aircraft always the best choice to rebuild a network when cargo prices are high? LNA will answer that question in the next part of the series.
Summary
- A pre-COVID19 fragmentation momentum;
- Pandemic turns long-haul business upside down;
- The appeal of long-range single-aisle aircraft assumes normal cargo prices;
- What a single-aisle airplane can’t provide.
Pontifications: Embraer’s strategy for the TPNG
By Scott Hamilton
Oct. 18, 2021, © Leeham News: It was October 2015 when Bjorn Fehrm and I first went to Sao Jose de Campos to visit Embraer’s headquarters. Among the topics discussed then was the prospect of developing a new turboprop airliner. The E2 program was well underway and one day, Embraer’s engineers would need something else to do.
At the time, officials weren’t enthusiastic about a turboprop. The cost to develop one was estimated to be about $2.5bn, about the same as the E2, they said. But the market was much smaller, only about 2,000-2,400 airplanes over 20 years.
Much has changed in six years. The E2 program is all but finished, with only the E175-E2 left. Periodic performance improvement packages will be developed. The proposed joint venture with Boeing, in which Embraer’s engineers were going to play a big role in two new airplane programs, is dead.
EcoAviation demands have risen to the forefront. Bombardier exited the Q400 turboprop business and the buyer, Longview Aviation Capital, “suspended” production during the COVID pandemic. Few believe it will be restarted. Airbus, which owns 50% of ATR, made hydrogen power a top priority. ATR may be the vehicle through which initial development is sold as a turboprop.
Air freight demand explosion: a long-term trend?
Subscription Required
By Judson Rollins
Introduction
October 18, 2021, © Leeham News: Much ink has been spilled over the surge in demand that has washed over every corner of the cargo world: air, sea, road, and rail.
Amazon Air’s first parcels being unloaded at Amazon.com’s new Cincinnati (US) sort hub. Source: Amazon.com.
Before the COVID-19 crisis, air transport was reserved primarily for items with high value and/or time sensitivity, such as laptop computers or express documents. And growing competition in the cargo market meant that average yield (revenue per ton-mile) was declining by more than 2% per year, according to past editions of Boeing’s World Air Cargo Forecast.
But now the cost of sea transport has exploded, shifting a significant chunk of cargo from ocean freighters to their airborne equivalents. This is driving some retailers to use air transport. Home Depot, an American home-improvement retailer, is resorting to air freight to bring in smaller, higher-value items like power tools that it needs to keep on the shelves at all times.
Even before COVID-19, a growing share of air freight has come from e-commerce — thereby shifting the volume-to-weight considerations relative to “traditional” freight.
Will these trends continue even beyond the COVID crisis? And what impact will it have on the market for factory-built freighters and passenger-to-freighter (P2F) conversions?
Summary
- Soaring sea freight yields mean small shipments are now more economic by air than sea.
- Volumetric capacity matters more than max gross weight.
- New freighter options will compete with a glut of conversion feedstock.
- Air freight yields will eventually revert to historical trendlines in most regions.
Bjorn’s Corner: The challenges of airliner development. Part 25. Safety monitoring and reporting
By Bjorn Fehrm, Henry Tam, and Andrew Telesca
October 15, 2021, ©. Leeham News: Last week, we introduced the activities around Continued Airworthiness that we have to do during development and flight testing of our aircraft.
As described, the majority of accidents for aircraft are attributed to failings in Continued Airworthiness and Operations rather than design. We listed Continued Operational Safety, Operational Preparedness, and Service Readiness as the three important areas for Continued Airworthiness.
We dive into Continued Operational Safety first, specifically Safety Monitoring and Reporting.
Figure 1. A graph showing how an OEM and FAA surveys the operation of an aircraft and takes action. Source: Boeing.